In my previous Torqeedo install article I left off that there was some small issues with the performance due to the limit of the manufacturers motor shaft length.  In the install manual it states the boom shaft that attaches to the ball on the kayak is to be completely level. Well this is found to be false. Pitching the boom down towards the water is the fix.

A support brace was custom made by a certified Torqeedo installer which mounts from the factory rudder mount threaded insert location. custom mount2 opaicOn the stern of the Big Rig you will notice the two brass threaded inserts molded into the hull. The rubber brace was removed from the kayak position and mounted to the custom bracket to brace the boom closer to the motor and allow the pitch.

The longer shaft allows the motor to use the small pitch and gain about 4 inches deeper into the water which was necessary to fix the cavitation issue. The gain on speed is minimal from the testing i have done but has not been tested in the control venue at Round Valley Res where the first test was initiated.

Lessons learned. If I was to  install this motor on another Jackson Big Rig I would mount the ball on the flat area about 6″ towards the stern. This would have allowed me to angle the boom down more. For me this was the first time following the installation book was wrong. The setup however did work just not well enough for my liking.

The Torqeedo motor system on the Big Rig is awesome! I do recommend it highly. This was my fix. Hopefully your install will be smoother by following my posts on The Plastic Hull.net.

 

Good Luck!

 

 

Disclaimer:

Installing hardware may cause damage and/or void manufacturer warranties.  ThePlasticHull.net its authors or any other source of information on this website is in no way responsible for your actions nor any type issues or damage that may occur.  The information provided on this website is a free reference guide only. The authors of all information, sponsors and the owners of the website that host this information are not liable for any problems or issues that arise from the use of this information. Users of this information hereby acknowledge that all use of this information is done by their own free will, at their own sole risk, understanding that destruction of property, injury, or death could occur.

Other Torqeedo Posts:

403 ultralight

403 ultralight post freature2

 

 

 

Weather predictions are rarely correct in the marine environment. From my experience they are typically close or way off. This past Saturday was the well off experience. Weather predictions for the area were winds light and variable seas 1-3 inches. I knew something wasn’t right prior to leaving the house around 5:00 am. It was already breezy. A quick text to Capt. Jim and the typical Capt Jim response “It’ll lay down”.

Met Jim at the drop in and well it was really windy but hell we went out anyway. About 100 yards from shore begun to understand how rough it was. Paddled past a boat with two old times aboard. They just looked and i could tell they were thinking to themselves we were crazy. I asked one of them if they had seen any bunker around. The guy just nodded that he did not.

The waves were immense at 3-4 foot but manageable as paddling into them was better than going sideways. Two miles later reaching the area of the Raritan Reach channel planned to fish. Attempted to fish but it was just to rough too fast of a drift and really felt unsafe. The options arose. Beach on Staten Island and wait a little while to see if the wind was going to lay down. Or high tale it back to the launch to go fish the bay side of Sandy Hook. It took about 5 minutes and we were turned around bow to land. Back to  the drop in. The ride in with the large waves and following sea was uneasy but an easy paddle back.

Once loaded up it was about a 40 min drive roughly 30 miles driving distance to the tip of Sandy Hook. The location is Fort Hancock which was an army fort built to defend the waterways and ports to New York City active from 1859 then decommissioned in 1974. It is now a national park and is part of the Gateway National Park System. There are many other things to do in the park that involve the outdoors.cuda short fluke (Large)

So it was much calmer since the land blocks the wind and waves that were full force at the previous location. We dropped in and begun to fish. There were a few other kayak anglers there of whom I knew one of them. They stated the fishing wasn’t really good and the incoming tide was against the wind there.

It seemed to be a slow pick but there are big fish in the area. I ended up loosing one because it wouldn’t fit in my net. A few more short fish for the day the largest landed by myself being a 15.5 incher. Jim had a decent one over 19″. The drift was fast and i couldn’t hold bottom with a 3 oz Spro. Jim was using what looked like minimal a 4 oz huge buck tail. It wasn’t long after that 3:30 Pm rolled around and called it a day.

Once on shore and walking your yaks through a wedding setup a park ranger came by and checked our catch and asked us a few questions. She was actually pleasant to communicate with.

This concluded the fishing trip. It was a nice ride home although I was exhausted. Im looking forward to getting out on the water again asap.

Check back for more fishing journal entries in the future!

 

 

Although this was the NJ HOW Chapters third time hosting an event at the Port Monmouth venue it was my first time running one as the Event Coordinator.NYC Skyline (Large)

Managing an event like this helps you appreciate how much work actually goes into the event and the time it takes to make the event successful. Then the great feeling once the event has concluded and to see the smiles from the people we do it for.

Our Photographer Val and I

Its priceless and worth every second of my time. Its also great to hang out with fellow volunteers whom spend their time making these events possible.

The Port Monmouth Event at the Bayshore Waterfront park is one of the best bay events as the spring time this area typically has very good Fluke fishing.  Its scenery is also extravagant on a clear day as you can see the New York City sky line along with the Navy Earl Ammunition Pier & Waterfront Complex which is located about a mile south.

The sandy beach provides a nice drop in besides the soft sandy walk down. It becomes a true test for kayak carts of all shapes & sizes on the way back up after the day is over.

My day started at 4:30 AM as i arose from my slumber. I was out of the house by 5:00 Am to pickup a coffee and a bite to eat. After that it was off to the bay shore. Stopping on the way for 5 dozen Dunkin Donuts and 5 boxes of coffee for the event.gene 26in fluke (Large)

Arriving at the park at 6:15 some volunteers had already arrived. Sean redneck pointing to his watch as if I was late. Begun to unload as more volunteers showed up lifting plastic boats from their car top cradles and trailers. As they geared up their boats the trailers eventually showed up with the HOW gear and the volunteers were quick to unload and create a rig tying group a kayak unloading group and group to make up separate cups of bait for each veteran kayak. The land crew eventually came and the event direction signs were set up and a light breakfast was set up. Bagels Donuts and Coffee was on the menu.

Soon our Heroes arrived! The men and women whom were wounded while fighting for us. It was to be their day!

9:00 PM headed up a captains meeting and a quick launch as the wind was already starting to get strong by this time. After about 2 hours i heard over the radio that one of the Veterans Gene had landed a 26″ fluke (pictured right)! Nice fish!!

I heard of a few fish caught but the drift along with the wind was a challenge. One of our tandems ended up being blown way south and we had to pick up the duo by car. With the winds at 10-15 and lunch being cooked by Ed Danberry and Civic Duty Partners a charity group that supports Heroes on the water NJ Veterans and guides began landing on the beach.

Lunch was incredible consisting of Burgers Dogs and the famous sausages with all of the fixings paired along with cold sides and cookies for dessert. Great Job done by CDP once again!

After lunch concluded everyone was pretty much done fishing. This was completely understandable as it was most likely more paddling than fishing.  All the volunteers again grouped together to get the cleanup and pack up done. It went flawless. One of the volunteers had set up a whole cleaning station for gear boats and tackle.  Everything worked like a assembly line in reverse from the morning.

Im glad the vets had a great time despite the windy day on the water. I would like to tank all of the volunteers who attended the event. You all did an amazing job and I could not have asked for better!

 

See you all at the next event!